| Citation: | Tjokorda I. Indira, Khairul Hadi Burhan, Robert Manurung, Ana Widiana. Enhancement of Essential Oil Yield from Melaleuca Leucadendra L. Leaves by Lignocellulose Degradation Pre-Treatment Using Filamentous Fungi[J]. Journal of Bioresources and Bioproducts, 2021, 6(4): 379-386. doi: 10.1016/j.jobab.2021.02.010
|
The essential oil from Melaleuca leucadendra L. leaves has been widely used as a perfume and traditional remedy, cosmetics and pharmaceutical products ingredient since many years ago. The common technology to recover the oil is hydro-distillation and steam-distillation. However, all oil can not be fully extracted from the leaves by this method due to the recalcitrant structure of leaves that hindrance the access of the solvent. Adding a submerged fermentation as a pre-treatment step prior to the extraction process helped to loosen the lignocellulose structure and enhance oil release in the extraction process. In this study, the raw materials were collected from the natural forest in Buru Island, Maluku, Indonesia. The biological agents applied in these processes were Phanerochaete chrysosporium ITBCC136 and Trichoderma viride ITBCC143. The oil extraction process was conducted by method of steam-distillation, the oil was analysed using gas chromatography-mass spectroscopy (GC-MS), and the lignocellulose content in the biomass was measured by the fractionation method. The treatment using T.viride provided the highest increase in yield percentage up to 3.47% as compared with control of 1.45%, with the lowest percentages of the remained cellulose, while the fermentation with the presence of P.chrysosporium did not affect the oil yield even the lignin content was decrease as much as 21%. The percentages of 1, 8-cineole in the oil were almost unchanged, which was about 20% of the oil.
|
Abu Bakar, A., Sulaiman, S., Omar, B., Mat Ali, R., 2012. Evaluation of Melaleuca cajuputi (Family: Myrtaceae) essential oil in aerosol spray cans against dengue vectors in low cost housing Flats. J. Arthropod Borne Dis 6, 28-35.
|
|
Agustina, Z.A., Suharmiati, S., 2017. Pemanfaatan minyak kayu putih (Melaleuca leucadendra linn) sebagai alternatif pencegahan kasus infeksi saluran pernafasan akut di pulau buru. J. Kefarmasian Indonesia 7, 120-126. http://www.researchgate.net/publication/319468548_Pemanfaatan_Minyak_Kayu_Putih_Melaleuca_leucadendra_Linn_sebagai_Alternatif_Pencegahan_Kasus_Infeksi_Saluran_Pernafasan_Akut_di_Pulau_Buru
|
|
Ali, B., Al-Wabel, N.A., Shams, S., Ahamad, A., Khan, S.A., Anwar, F., 2015. Essential oils used in aromatherapy: a systemic review. Asian Pac. J. Trop. Biomed. 5, 601-611. doi: 10.1016/j.apjtb.2015.05.007
|
|
Anwar, Z., Gulfraz, M., Irshad, M., 2014. Agro-industrial lignocellulosic biomass a key to unlock the future bio-energy: a brief review. J. Radiat. Res. Appl. Sci. 7, 163-173. doi: 10.1016/j.jrras.2014.02.003
|
|
Baruah, J., 2018. Recent trends in the pretreatment of lignocellulosic biomass for value-added products. Front. Energy Res. 6, 19. doi: 10.3389/fenrg.2018.00019
|
|
Behnood, M., Nasernejad, B., Nikazar, M., 2014. Biodegradation of crude oil from saline waste water using white rot fungus Phanerochaete chrysosporium. J. Ind. Eng. Chem. 20, 1879-1885. doi: 10.1016/j.jiec.2013.09.007
|
|
Benner, R., Hodson, R.E., 1985. Microbial degradation of the leachable and lignocellulosic components of leaves and wood from Rhizophora mangle in a tropical mangrove swamp. Mar. Ecol. Prog. Ser. 23, 221-230. doi: 10.3354/meps023221
|
|
Blanchette, C., Lacayo, C.I., Fischer, N.O., Hwang, M., Thelen, M.P., 2012. Enhanced cellulose degradation using cellulase-nanosphere complexes. PLoS One 7, e42116.
|
|
Budiadi Kanazawa, Y., Ishii, H.T., Sabarnurdin, M.S., Suryanto, P., 2005. Productivity of kayu putih (Melaleuca leucadendron LINN) tree plantation managed in non-timber forest production systems in Java, Indonesia. Agrofor. Syst. 64, 143-155. doi: 10.1007/s10457-004-0777-6
|
|
Canam, T., Town, J., Iroba, K., Tabil, L., Dumonceaux, T., 2013. Pretreatment of lignocellulosic biomass using microorganisms: approaches, advantages, and limitations. Sustainable Degradation of Lignocellulosic Biomass-Techniques, Applications and Commercialization. U.K. : InTech.
|
|
Chintagunta, A.D., 2013. Enzymatic saccharification of pretreated lemon peels for fermentable sugar production enzymatic saccharification of pretreated lemon peels for fermentable sugar. J. Clean. Prod. 47, 347-355.
|
|
Coelho-Moreira Jda, S., Bracht, A, , de Souza, A.C., Oliveira, R.F., de Sá-Nakanishi, A.B., de Souza, C.G., Peralta, R.M., 2013. Degradation of diuron by Phanerochaete chrysosporium: role of ligninolytic enzymes and cytochrome P450. Biomed. Res. Int. 251354. http://www.onacademic.com/detail/journal_1000037951158510_df4a.html
|
|
Cuong, N.D., Xuyen, T.T., Motl, O., Stránský, K., Presslová, J., Jedlicková, Z., Serý, V., 1994. Antibacterial properties of Vietnamese cajuput oil. J. Essent. Oil Res. 6, 63-67. doi: 10.1080/10412905.1994.9698326
|
|
Datta, A., Bettermann, A., Kirk, T.K., 1991. Identification of a specific manganese peroxidase among ligninolytic enzymes secreted by Phanerochaete chrysosporium during wood decay. Appl. Environ. Microbiol. 57, 1453-1460. doi: 10.1128/aem.57.5.1453-1460.1991
|
|
Datta, R., 1981. Acidogenic fermentation of corn stover. Biotechnol. Bioeng. 23, 61-77. doi: 10.1002/bit.260230106
|
|
El Baz, A.F., Shetaia, Y.M.H., Shams Eldin, H.A., El Mekawy, A., 2018. Optimization of cellulase production by Trichoderma viride using response surface methodology. Curr. Biotechnol. 7, 19-25. doi: 10.2174/2211550105666160115213402
|
|
Fall, R., Ngom, S., Sall, D., Sembène, M., Samb, A., 2017. Chemical characterization of essential oil from the leaves of Callistemon viminalis (D.R.) and Melaleuca leucadendron (Linn.). Asian Pac. J. Trop. Biomed. 7, 347-351.
|
|
Farag, R.S., Shalaby, A.S., El-Baroty, G.A., Ibrahim, N.A., Ali, M.A., Hassan, E.M., 2004. Chemical and biological evaluation of the essential oils of different Melaleuca species. Phytother. Res. 18, 30-35. doi: 10.1002/ptr.1348
|
|
Fortkamp, D., Knob, A., 2014. High xylanase production by Trichoderma viride using pineapple peel as substrate and its apllication in pulp biobleaching. Afr. J. Biotechnol. 13, 2248-2259. doi: 10.5897/AJB2013.13479
|
|
Galadima, A.I., Salleh, M.M., Hussin, H., Mohd Safri, N., Mohd Noor, R., Chong, C.S., Yahya, A., Mohamad, S.E., Abd-Aziz, S., Yusof, N.N.M., Abu Naser, M., Al-Junid, A.F.M., 2020. One-step conversion of lemongrass leaves hydrolysate to biovanillin by Phanerochaete chrysosporium ATCC 24725 in batch culture. Waste Biomass Valorization 11, 4067-4080. doi: 10.1007/s12649-019-00730-w
|
|
Giovannoni, M., Gramegna, G., Benedetti, M., Mattei, B., 2020. Industrial use of cell wall degrading enzymes: the fine line between production strategy and economic feasibility. Front. Bioeng. Biotechnol. 8, 356. doi: 10.3389/fbioe.2020.00356
|
|
Gupta, J.K., Gupta, Y.P., Das, N.B., 1973. Degradation of cellulosic materials by Trichoderma viride cellulase. Agric. Biol. Chem. 37, 2657-2662. doi: 10.1080/00021369.1973.10861040
|
|
Heikal, A.A.E.M., 2017. Variation in the essential oil content and its composition in Eucalyptus cinerea leaves and its relation to some environmental factors. J. Essent. Oil Bear. Plants 20, 995-1005. doi: 10.1080/0972060X.2017.1351896
|
|
Huynh, Q., Phan, T.D., Thieu, V.Q., Tran, S.T., Do, S.H., 2012. Extraction and refining of essential oil from Australian tea tree, Melaleuca alterfornia, and the antimicrobial activity in cosmetic products. J. Phys. : Conf. Ser. 352, 012053. doi: 10.1088/1742-6596/352/1/012053/pdf
|
|
Ishii, H., Sunarto, H.T., S., Kanazawa, Y., 2005. Variation in kayu putih (Melaleuca leucadendron LINN) oil quality under different farming systems in Java, Indonesia. Eurasian J. For. Res. 8, 15-20. http://www.researchgate.net/profile/Budiadi_Budiadi/publication/37559387_Variation_in_Kayu_Putih_(Melaleuca_leucadendron_LINN)_Oil_Quality_under_Different_Farming_Systems_in_Java_Indonesia/links/551a78410cf26cbb81a2dbb5.pdf
|
|
Ismanto, A.W., Kusuma, H.S., Mahfud, M., 2017. Comparison of microwave hydrodistillation and solvent-free microwave extraction of essential oil from Melaleuca leucadendra Linn. IOP Conf. Ser. : Earth Environ. Sci. 101, 012014. doi: 10.1088/1755-1315/101/1/012014/pdf
|
|
Jajaei, S.M., Daud, W.R.W., Markom, M., Zakaria, Z., Presti, M.L., Costa, R., Mondello, L., Santi, L.C., 2010. Extraction of Melaleuca cajuputi using supercritic fluid extraction and solvent extraction. J. Essent. Oil Res. 22, 205-210. doi: 10.1080/10412905.2010.9700304
|
|
Janusz, G., Pawlik, A., Sulej, J., Swiderska-Burek, U., Jarosz-Wilkolazka, A., Paszczynski, A., 2017. Lignin degradation: microorganisms, enzymes involved, genomes analysis and evolution. FEMS Microbiol. Rev. 41, 941-962. doi: 10.1093/femsre/fux049
|
|
Kadarmoidheen, M., Saranraj, P., Stella, D., 2012. Effect of cellulolytic fungi on the degradation of cellulosic agricultural wastes. Int. J. Appl. Microbiol. Sci. 1, 11. http://www.researchgate.net/profile/Saranraj_JP/publication/259495562_EFFECT_OF_CELLULOLYTIC_FUNGI_ON_THE_DEGRADATION_OF_CELLULOSIC_AGRICULTURAL_WASTES/links/00b4952c45f4025f8a000000
|
|
Khasanah, L.U.R., Ananditho, B.K., Nugraheni, A.E., 2014. The effect of pretreatment solid and submerged fermentation on yield and quality of cinnamon leaf oil. Agritech, 34, 36-42.
|
|
Kim, J.H., Liu, K.H., Yoon, Y., Sornnuwat, Y., Kitirattrakarn, T., Anantachoke, C., 2005. Essential leaf oils from Melaleuca cajuputi. Acta Hortic. 680, 65-72. http://wwwlib.teiep.gr/images/stories/acta/Acta%20680/680_8.pdf
|
|
Li, X.H., Yang, H.J., Roy, B., Park, E.Y., Jiang, L.J., Wang, D., Miao, Y.G., 2010. Enhanced cellulase production of the Trichoderma viride mutated by microwave and ultraviolet. Microbiol. Res. 165, 190-198. doi: 10.1016/j.micres.2009.04.001
|
|
Mandey, J.S., Leke, J.R., Kaunang, W.B., Kowel, Y.H.S., 2015. Carcass yield of broiler chickens fed banana (Musa paradisiaca) leaves fermented with Trichoderma viride. J. Indonesian Trop. Anim. Agric. 40, 229-233. http://ejournal.undip.ac.id/index.php/jitaa/article/download/10400/8280
|
|
Moredo, N., Lorenzo, M., Domínguez, A., Moldes, D., Cameselle, C., Sanroman, A., 2003. Enhanced ligninolytic enzyme production and degrading capability of Phanerochaete chrysosporium and Trametes versicolor. World J. Microbiol. Biotechnol. 19, 665-669. doi: 10.1023/A:1025198917474
|
|
Mutschlechner, M., Illmer, P., Wagner, A.O., 2015. Biological pre-treatment: Enhancing biogas production using the highly cellulolytic fungus Trichoderma viride. Waste Manag. 43, 98-107. doi: 10.1016/j.wasman.2015.05.011
|
|
Nurhadianty, V., Sarosa, A.H., Wahyuningsih, I., Cahyani, C., 2020. Improving yield and quality characteristics of Kaffir lime oil (Citrus hystrix DC) by solid fermentation pretreatment using tempeh yeast. Mal. J. Fund. Appl. Sci. 16, 493-496. doi: 10.11113/mjfas.v16n4.1525
|
|
Pellinen, J., Abuhasan, J., Joyce, T.W., Chang, H.M., 1989. Biological delignification of pulp by Phanerochaete chrysosporium. J. Biotechnol. 10, 161-170. doi: 10.1016/0168-1656(89)90038-2
|
|
Pino, J., Bello, A., Urquiola, A., Aguero, J., Marbot, R., 2002. Chemical composition of cajuput oil (Melaleuca leucadendra L.) from Cuba. J. Essent. Oil Res. 14, 10-11. doi: 10.1080/10412905.2002.9699744
|
|
Pujiarti, R., Ohtani, Y., Ichiura, H., 2011. Physicochemical properties and chemical compositions of Melaleuca leucadendron leaf oils taken from the plantations in Java, Indonesia. J. Wood Sci. 57, 446-451. doi: 10.1007/s10086-011-1183-0
|
|
Pujiarti, R., Ohtani, Y., Widowati, T.B., 2012. Kasmudjo Utilization of Melaleuca leucadendron essential oil. 2, 94-99.
|
|
Rencoret, J., Gutiérrez, A., Nieto, L., Jiménez-Barbero, J., Faulds, C.B., Kim, H., Ralph, J., Martínez, A.T., del Río, J.C., 2011. Lignin composition and structure in young versus adult Eucalyptus globulus plants. Plant Physiol. 155, 667-682. doi: 10.1104/pp.110.167254
|
|
Schoemaker, H.E., Leisola, M.S.A., 1990. Degradation of lignin by Phanerochaete chrysosporium. J. Biotechnol. 13, 101-109. doi: 10.1016/0168-1656(90)90096-T
|
|
Shaw, J.J., Berbasova, T., Sasaki, T., Jefferson-George, K., Spakowicz, D.J., Dunican, B.F., Portero, C.E., Narváez-Trujillo, A., Strobel, S.A., 2015. Identification of a fungal 1, 8-cineole synthase from Hypoxylon sp. with specificity determinants in common with the plant synthases. J. Biol. Chem. 290, 8511-8526. doi: 10.1074/jbc.M114.636159
|
|
Siddique, S., Parveen, Z., Firdaus-E-bareen, Mazhar, S., 2020. Chemical composition, antibacterial and antioxidant activities of essential oils from leaves of three Melaleuca species of Pakistani flora. Arab. J. Chem. 13, 67-74. doi: 10.1016/j.arabjc.2017.01.018
|
|
Singh, D., Chen, S.L., 2008. The white-rot fungus Phanerochaete chrysosporium: conditions for the production of lignin-degrading enzymes. Appl. Microbiol. Biotechnol. 81, 399-417. doi: 10.1007/s00253-008-1706-9
|
|
Slamet, S., Ulyarti, U., Rahmi, S.L., 2019. Pengaruh Lama fermentasi terhadap rendemen Dan mutu fisik minyak nilam Pogostemon cablin Benth. J. Tek. Ind. Pert. Ind. 11, 19-25. doi: 10.17969/jtipi.v11i1.11671
|
|
Sreedharan, S., 2016. An overview on fungal cellulases with an industrial perspective. J. Nutr. Food Sci. 6, 1-13. http://www.openaccessjournals.com/scholarly-articles/an-overview-on-fungal-cellulases-with-an-industrial-perspective-2155-9600-1000461.pdf
|
|
Su, Y., Xian, H., Shi, S., Zhang, C., Manik, S.M., Mao, J., Zhang, G., Liao, W., Wang, Q., Liu, H., 2016. Biodegradation of lignin and nicotine with white rot fungi for the delignification and detoxification of tobacco stalk. BMC Biotechnol 16, 81. doi: 10.1186/s12896-016-0311-8
|
|
Ulmer, D.C., Leisola, M.S.A., Schmidt, B.H., Fiechter, A., 1983. Rapid degradation of isolated lignins by Phanerochaete chrysosporium. Appl. Environ. Microbiol. 45, 1795-1801. doi: 10.1128/aem.45.6.1795-1801.1983
|
|
Zhao, L., Cao, G.L., Wang, A.J., Ren, H.Y., Dong, D., Liu, Z.N., Guan, X.Y., Xu, C.J., Ren, N.Q., 2012. Fungal pretreatment of cornstalk with Phanerochaete chrysosporium for enhancing enzymatic saccharification and hydrogen production. Bioresour. Technol. 114, 365-369. doi: 10.1016/j.biortech.2012.03.076
|
|
Zhi, Z.L., Wang, H., 2014. White-rot fungal pretreatment of wheat straw with Phanerochaete chrysosporium for biohydrogen production: simultaneous saccharification and fermentation. Bioprocess Biosyst. Eng. 37, 1447-1458. doi: 10.1007/s00449-013-1117-x
|
Figures(5) / Tables(1)
WeChat: JournalBandBCopyright © 2019 Editorial Office of Journal of Bioresources and Bioproducts
Supported by: Beijing Renhe Information Technology Co. Ltd support: info@rhhz.net
DownLoad:
